Experimental and Numerical Study on Fatigue Crack Growth of Bridge Suspender

马亚飞; 陈志铖; 叶钧; 王磊; 张建仁

doi:10.13409/j.cnki.jdpme.2019.01.004

您当前的位置：

首页 >

文章列表页 >

Experimental and Numerical Study on Fatigue Crack Growth of Bridge Suspender

更新时间：2025-12-11

- Experimental and Numerical Study on Fatigue Crack Growth of Bridge Suspender
- Vol. 39, Issue 1, Pages: 23-30(2019)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：10.13409/j.cnki.jdpme.2019.01.004
  CLC： 446
- Published：2019
- 稿件说明：
移动端阅览
[1]马亚飞,陈志铖,叶钧,王磊,张建仁.桥梁吊索高强钢丝疲劳裂纹扩展试验与数值模拟[J].防灾减灾工程学报,2019,39(01):23-30.

马亚飞, 陈志铖, 叶钧, et al. Experimental and Numerical Study on Fatigue Crack Growth of Bridge Suspender[J]. 2019, 39(1): 23-30.
[1]马亚飞,陈志铖,叶钧,王磊,张建仁.桥梁吊索高强钢丝疲劳裂纹扩展试验与数值模拟[J].防灾减灾工程学报,2019,39(01):23-30. DOI： 10.13409/j.cnki.jdpme.2019.01.004.

马亚飞, 陈志铖, 叶钧, et al. Experimental and Numerical Study on Fatigue Crack Growth of Bridge Suspender[J]. 2019, 39(1): 23-30. DOI： 10.13409/j.cnki.jdpme.2019.01.004.

摘要

反复车辆荷载作用下

斜拉桥斜拉索及拱桥吊杆疲劳损伤问题日益严重。针对大跨桥梁中常用的镀锌高强钢丝

开展了应力比R分别为0.1、0.2、0.3的疲劳裂纹扩展试验

研究了应力比及应力幅对钢丝疲劳裂纹扩展性能的影响

每种应力比下的应力幅分别为140.4、152.1、163.8、175.5MPa。采用分步加载方法

设计不同加载应力幅在试件断裂面留下裂纹扩展时的条纹特征

利用光学显微镜对疲劳断口的疲劳条纹进行观测

得到了不同应力比下裂纹扩展深度与疲劳循环次数的a—N曲线

拟合了高强钢丝的疲劳裂纹扩展速率模型。试验结果表明:钢丝疲劳裂纹呈三阶段扩展

随着应力比R的增大

Paris公式中参数C变小

m变大。运用有限元软件ABAQUS模拟了裂纹扩展过程

定量分析了裂纹扩展径向与表面方向的关系

试验结果与有限元结果吻合较好。试验得到的疲劳裂纹扩展速率曲线

可用于大跨桥梁吊索的抗疲劳、防断裂设计及疲劳寿命评估。

Abstract

The fatigue damage for cable-stayed bridge cable and arch bridge hanger become serious under cyclic loadings.The fatigue crack growth tests for galvanized high strength steel wires that are widely used in large-span bridges were performed with stress ratios of R=0.1

0.2 and 0.3.The effects of stress ratio and stress amplitude on the fatigue crack propagation of steel wires were studied

and four stress amplitudes were considered

i.e.140.4 MPa

152.1 MPa

163.8 MPa and 175.5 MPa.A two-step loading method was selected in the tests.Fatigue stripes were presented in the fracture surface using different loading amplitudes

and the stripes of the fatigue fracture were observed by an optical microscope.The a-Ncurves related to the crack propagation depth and the fatigue cycles under different stress ratios were obtained.The curves of fatigue crack propagation rate of the steel wires under different stress ratios were also fitted.The experimental results show that fatigue crack propagation exhibited three stages.As stress ratio increases

the parameters C in Paris formula decreases and the parameter m increases.The crack propagation process was simulated by the finite element software ABAQUS

and the relationship between the radial direction and the surface direction of crack growth is quantitatively analyzed.The experimental results are in good agreement with the finite element simulation results.The obtained curves of fatigue growth rate can be used for fatigue design

fracture control and fatigue life assessment for existing large-span bridge suspender.

关键词

Keywords

references

腐蚀吊索钢丝力学性能退化研究 [J]. 乔燕,李爱群,缪长青,孙传智. 中外公路 . 2016(03)

拱桥吊杆锈蚀高强钢丝疲劳性能试验研究 [J]. 李晓章,谢旭,潘骁宇,孙文智,朱汉华. 土木工程学报 . 2015(11)

锈蚀高强度钢丝的力学性能与评级方法 [J]. 潘骁宇,谢旭,李晓章,孙文智,朱汉华. 浙江大学学报(工学版) . 2014(11)

带裂纹的悬索桥主缆钢丝的断裂强度分析 [J]. 曾勇,陈艾荣,马如进. 同济大学学报(自然科学版) . 2009(08)

在役钢管混凝土拱桥吊杆损伤与系统可靠性分析方法 [D]. 高欣. 哈尔滨工业大学 2011

一种冷拔高强钢丝裂纹扩展速率的简易检测方法 [P]. 徐俊,陈惟珍,周健鸿,李佳,张博珊,杨清梅. 中国专利:CN103868808A,

Fatigue life prediction for aging RC beams considering corrosive environments [J] . Yafei Ma,Yibing Xiang,Lei Wang,Jianren Zhang,Yongming Liu. Engineering Structures . 2014

Experimental Study on Fatigue Strength of Corroded Bridge Wires [J] . Shunichi Nakamura,Keita Suzumura. Journal of Bridge Engineering . 2013 (3)

Effect of crack shape and size on estimating the fracture strength and crack growth fatigue life of bridge cable steel wires [J] . G. C. Sih,X. S. Tang,K. M. Mahmoud,M. K. Kassir. Bridge Structures . 2008 (1)

Fracture strength for a high strength steel bridge cable wire with a surface crack [J] . K.M. Mahmoud. Theoretical and Applied Fracture Mechanics . 2007 (2)

Fatigue crack growth behavior of cables and steel wires for the cable-stayed portion of Runyang bridge: Disproportionate loosening and/or tightening of cables [J] . G.C. Sih,X.S. Tang,Z.X. Li,A.Q. Li,K.K. Tang. Theoretical and Applied Fracture Mechanics . 2007 (1)

Wire fractures in locked coil cables [J] . Bridge Structures . 2006 (2)

Mechanical Properties and Remaining Strength of Corroded Bridge Wires [J] . Nakamura,Suzumura,Tarui. Structural Engineering International . 2004 (1)

Accelerated Corrosion and Embrittlement of High-Strength Bridge Wire [J] . Scott Calabrese Barton,Garry W. Vermaas,Paul F. Duby,Alan C. West,Raimondo Betti. Journal of Materials in Civil Engineering . 2000 (1)

Views

249

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

⁰