基于地层⁃注浆体⁃管片协同作用的海底盾构隧道受力研究∗
Stress Analysis of Subsea Shield Tunnel Based on Synergistic Effect of Stratum, Grouting and Lining Segment
- 防灾减灾工程学报 2023年43卷第2期 页码：373-386
- 作者机构：
厦门理工学院土木工程与建筑学院,福建,厦门,361024
- 作者简介：
- 基金信息：福建省自然科学基金计划项目(2022J011252)、厦门市建设局科技项目(XJK-2021-9)资助
DOI：
中图分类号： U455.43-
纸质出版：2023
- 稿件说明：
移动端阅览
施有志. 基于地层⁃注浆体⁃管片协同作用的海底盾构隧道受力研究∗[J]. 防灾减灾工程学报, 2023,43(2):373-386.
施有志,赵花丽,林树枝.基于地层⁃注浆体⁃管片协同作用的海底盾构隧道受力研究∗[J].防灾减灾工程学报,2023,43(2):373-386
摘要
为研究海底盾构隧道中浆液与围岩及管片的相互作用特性，以厦门地铁 2 号线海底盾构段为工程背景，采用数值模拟方法和现场实测方法，分析注浆的浆液凝固过程，重点研究浆液的抗压强度、刚度、收缩、蠕变等特性对隧道力学和变形的影响特征，以及不同地层分布、不同隧道埋深下的管片受力特征，并采用流固耦合研究海水位变化对管片受力的影响。计算研究表明：注浆材料的刚度比 E1/E28对管片最终轴力和围岩压力影响小，变化幅度不超过 0.885%，对地层变形影响相对较大，可通过添加剂调节凝结时间，尽量让浆液早一些凝固硬化；最终收缩应变增大， 隧道内力和外侧压力降低，地层沉降增大，建议采用泌水率低的浆液，且其收缩值需控制在较小的范围内；蠕变参数取值对管片轴力影响较小，变化幅度最大不超过 1.35%；收缩参数主要考虑注浆材料后期的凝固收缩，蠕变则主要考虑注浆材料前期的蠕变收缩；地层变化及隧道埋深变化对隧道管片受力影响显著，隧道拱顶若软土较厚，则不易形成有效压力拱，导致围岩压力荷载较大；半日潮对地层变形、管片受力的影响不大，总体发展趋势与静水位条件下相似。最后，监测结果表明，数值模拟与实测的管片水土压力时程变化规律基本一致。
Abstract
The interaction characteristics of cement paste with surrounding rock and lining segment in a subsea shield tunnel were studied by taking the subsea shield section of Xiamen Metro Line 2 as the engineering background. Numerical simulation and field measurement were carried out to analyze the solidification process of grouting slurry， focusing on the influence characteristics of compressive strength， stiffness， shrinkage and creep of cement paste on mechanical behavior and deformation of the tunnel， and the stress characteristics of the lining segment with different strata distribution and dif-ferent tunnel depths. Also， the influence of sea water level change on the stress of the lining segment was studied by the fluid-structure coupling technique. The calculation results show that the stiffness ra-tio E1/E28 of grouting material has less influence on the final axial force of the lining segment and the pressure of surrounding rock， producing a variation range of no more than 0.885%， while has a large influence on formation deformation. The setting time can be adjusted by additives to make the grout solidify and harden as early as possible； It is suggested that the grout with a low bleeding rate should be used， and its shrinkage value should be controlled in a small range； The creep parameters have lit-tle effect on the axial force，with a maximum variation range of less than 1.35； The shrinkage parame-ter mainly considers the solidification shrinkage of grouting material in the later stage， while creep pa-rameter mainly considers the creep shrinkage of grouting material in the earlier stage； If the soft soil is thick， the effective pressure arch is not easy to form， which leads to a large surrounding rock pres-sure； The semidiurnal tide has little effect on stratum deformation and segment stress， and the general development trend is similar to that under the static water level. Finally， the monitoring results show that the numerical simulated time history variation law of soil and water pressure in the segment is ba-sically consistent with the measured one.
关键词
Keywords
references
陈路海,郤保平,熊贵明,等.基于流固耦合作用的迎泽湖下盾构隧道稳定性分析[J].水电能源科学,2019,37(7):94-98.Chen L H,Ying B P,Xiong G M,et al.Stability anal?ysis of shield tunnel under Yingze Lake based on fluidsolid coupling [J].Water Resources and Power,2019,37(7):94-98.(in Chinese)
李军,黄帅,黄林冲,等.跨江泥水盾构掘进过程中的沿江路段地表变形特征[J].铁道科学与工程学报,2019,16(5):1252-1259.Li J,Huang S,Huang L C,et al.Surface deformationcharacteristics cross the river during slurry shield tunnel?ing [J].Journal of Railway Science and Engineering,2019,16(5):1252-1259.(in Chinese)
张金龙,苟长飞,叶飞.大断面跨海盾构隧道结构设计与参数分析[J].现代隧道技术,2020,57(2):61-67.Zhang J L,Gou C F,Ye F.Structural design and pa?rameter analysis of a large-section sea-crossing shieldtunnel [J].Modern Tunnelling Technology,2020,57(2):61-67.(in Chinese)
郤保平,陈路海,董赟盛.基于流-固耦合理论的水体下盾构隧道施工渗流规律[J].太原理工大学学报,2020,51(5):634-640.Ying B P,Chen L H,Dong F S.Seepage law of shieldtunnel construction under water body based on fluid-sol?id coupling theory [J].Journal of Taiyuan University ofTechnology,2020,51(5):634-640.(in Chinese)
朱合华,丁文其,桥本正.盾构隧道施工过程模拟分析[J].岩石力学与工程学报,1999,18(增 1):860-864.Zhu H H,Ding W Q,Qiao B Z.Simulation analysis ofshield tunnel construction process [J].Journal of RockMechanics and Engineering,1999,18(Sup1):860-864.(in Chinese)
韩月旺,钟小春,虞兴福.盾构壁后注浆体变形及压力消散特性试验研究[J].地下空间与工程学报,2007,3(6):1142-1147.Han Y W,Zhong X C,Yu X F.Experimental researchon the backfill grout deformation and grout pressure dis?sipation of shield tunnel [J].Journal of UndergroundSpace and Engineering,2007,3(6):1142-1147.(inChinese)
袁小会,韩月旺,钟小春.盾尾注浆硬性浆液固结变形数值计算模型构建[J].岩土力学,2012,33(3):925-932.Yuan X H,Han Y W,Zhong X C.Numerical modelbuilding for consolidation deformation of cemented mor?tar for shield tail grouting [J].Rock and Soil Mechan?ics,2012,33(3):925-932.(in Chinese)
Kasper T,Meschke G.On the influence of face pres?sure,grouting pressure and TBM design in soft groundtunneling [J].Tunnelling & Underground Space Tech?nology,2006,21(2):160-171.
Swoboda G,Abu-Krisha A.Three-dimensional numeri?cal modeling for TBM tunneling in consolidated clay[J].Tunnelling & Underground Space Technology,1999,14(3):327-333.
Komiya K.Soil consolidation associated with groutingduring shield tunnelling in soft clayey ground [J].Géotechnique,2001,51(10):835-846.
万战胜,朱岱云,夏永旭.盾构隧道壁后注浆对地表沉降影响数值模拟研究[J].河北工业大学学报,2011,40(1):110-113.Wan Z S,Zhu D Y,Xia Y X.Numerical simulationstudy of settlement on shield tunnel after grouting ofwall formation [J].Journal of Hebei University of Tech?nology,2011,40(1):110-113.(in Chinese)
张云,殷宗泽,徐永福.盾构法隧道引起的地表变形分析[J].岩石力学与工程学报,2002,21(3):388-392.Zhang Y,Yin Z Z,Xu Y F.Analysis on three-dimen?sional ground surface deformations due to shield tunnel[J].Journal of Rock Mechanics and Engineering,2002,21(3):388-392.(in Chinese)
施有志,林树枝,车爱兰.基于深基坑监测数据的土体小应变刚度参数优化分析[J].应用力学学报,2017,34(4):654-660.Shi Y Z,Lin S Z,Che A L.Optimization analysis ofthe soil small strain stiffness parameters based on deepfoundation pit monitoring data [J].Journal of AppliedMechanics,2017,34(4):654-660.(in Chinese)
王树清,蔡胜华,蒋硕忠.盾构法隧道施工同步注浆材料研究[J].长江科学院学报,1998,15(4):28-31.Wang S Q,Cai S H,Jiang S Z.Study on simultaneous grouting material for shield tunnel [J].Journal of Yang?tze River Sciences Research Institute,1998,15(4):28-31.(in Chinese)
付磊.盾构隧道施工中的注浆材料特性研究及其引起的地层变形规律分析[D].南京:河海大学,2007.Fu L.Study of characteristics of grouting material in itsapplication in deformation calculation of tunnel construc?tion [D].Nanjing:Hehai University,2007.(in Chi?nese)
Prediction of Creep,Shrinkage,and Temperature Ef?fects in Concrete Structures:ACI 209R-1992(R2008)[S].2008.
Schütz R,Potts D M,Zdravkovic L.Advanced consti?tutive modelling of shotcrete:Model formulation andcalibration [J].Computers & Geotechnics,2011,38(6):834-845.
Schweiger H F,Marcher T,Sch?dlich B.Applicationof a new shotcrete constitutive model to the numericalanalysis of a tunnel excavation[C]∥Tunneling and Un?derground Construction:2014 Geoshanghai Internation?al Congress.Shanghai:American Society of Civil Engi?neers,2014:890-899.
Sch?dlich B,Schweiger H,Marcher T,et al.Rock en?gineering and rock mechanics:structures in and on rockmasses[M].Leiden:CRC Press Taylor & FrancisGroup,2014:799-804.
朱建春,李乐,杜文库.北京地铁盾构同步注浆及其材料研究[J].建筑机械化,2004,25(11):26-29.Zhu J C,Li L,Du W K.Research on shield machineconstruction with pouring mortar simultaneously andmortar materials in Beijing subway [J].ConstructionMechanization,2004,25(11):26-29(in Chinese)
矫伟刚,丁彦杰,张凯,等.盾构新型同步注浆浆液性能试验对比研究[J].施工技术,2016,45(增 1):484-487.Jiao W G,Ding Y J,Zhang K,et al.Study on slurryperformance of new type synchronous grouting in shieldconstruction [J].Construction Technology,2016,45(Sup1):484-487.(in Chinese)
许黎明.基于监测与计算的海底风化槽地铁盾构隧道结构受力性能分析[J].中外公路,2020,257(5):228-234.Xu L M.Analysis of mechanical performance of subseaweathered trench metro shield tunnel based on monitor?ing and calculation [J].Journal of China & ForeignHighway,2020,257(5):228-234.(in Chinese)
0
浏览量
398
下载量
0
CSCD
- Meta-XML下载
- BibTeX下载
- Endnote下载
- RefMan 下载
- NoteExpress下载
- NoteFirst下载
关联资源
相关文章
相关作者
相关机构
- 技术支持由北京北大方正电子有限公司提供 苏ICP备05012539号-11
苏公网安备32010202012147号 - 本系统建议在Chrome、 IE9+ 以上版本浏览器阅读本站内容，360浏览器请切换至极速模式
- Cookies帮助我们提供服务并提供个性化体验。使用本网站，即表示您同意我们使用Cookies
